Product ID:BASE 1 ALKYD FLOOR ENAMEL, 630-91
MSDS Date:06/02/1986
FSC:8010
NIIN:00N034506
MSDS Number: BQBRL

O BRIEN CORP

450 EAST GRAND AVE
SOUTH SAN FRANCISCO, CA 94080
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 415-761-2300

Cage: 30806

O BRIEN CORPORATION

SOUTH SAN FRANCISCO, CA 94080-6207 US

Cage: 72556

RPTS HAVE ASSOC PRLNGD & RPTD OCCUP OVEREXP TO SOLV

RTECS: 9999999ZZ

DELIB CONC & INHALING CONTENTS MAY BE HARMFUL/FATAL.

RTECS: 9999999ZZ

KIDNEYS, LIVER, LUNGS, BLOOD CELLS, BLOOD PRODUCING

RTECS: 9999999ZZ

PERIPHERAL NERVOUS SYSTEM.

RTECS: 9999999ZZ

(ORAL,RAT) 4300 MG/KG.

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: <5%

OSHA PEL 100 PPM;150 PPM STEL

ACGIH TLV: 100 PPM;150 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

5.

CAS: 64742-88-7

Fraction By Weight: 30%

OSHA PEL 100 PPM (MFR)

ACGIH TLV: 500 PPM (MFR)

2.

CAS: 64742-88-7

Fraction By Weight: <5%

OSHA PEL 500 PPM (MFR)

ACGIH TLV: 350 PPM (MFR)

(ORAL,RAT) 9500

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 25%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

STAG GAIT, CONFUSN, LOSS OF

RTECS: 9999999ZZ

CAUSES IRRIT.PRLNGD/RPTD CONT MAY RSLT IN

RTECS: 9999999ZZ

STUDIES SHOW PROD IS

RTECS: 9999999ZZ

STUDIES SHOW THAT PROD CAUSES DMG TO HEART IN

RTECS: 9999999ZZ

LAB STUDIES SHOW THAT INHAL EXPOS TO HIGH

RTECS: 9999999ZZ

RATS. THIS RESPONSE DID NOT OCCUR AT LOWER EXPOS LEVS

RTECS: 9999999ZZ

LUNG CLEARANCE MECHANISMS. RELEVANCE OF DATA TO

RTECS: 9999999ZZ

LD50 LC50 Mixture:SEE INGREDIENTS 1 AND 4.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: ING 1/ING 2/ING 3: INGEST:
ASPIR OF MATL INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM WHICH
CAN BE FATAL.DECISION TO INDUCE VOMIT MUST BE BASED ON MED ADVICE
FROM PHYS/POIS CNTRL CNTR. ING 4: I NGEST: LOW ORAL TOX. NO TOX
EFTS DUE TOINGEST ARE DESCRIBED IN LITERATURE. INHAL: IRRIT TO
UPPER RESP (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: TRACT. EYE:IRRIT. INGEST:CAUSES IRRIT
TO MOUTH, THROAT, & GI TRACT W/ACUTE CNS DEPRESS.SYMP MAY INCL
HDCH, DIZZ, CONFUSN, NAUS, VOMIT, ABDOMINAL PAIN,DIARR, LOSS OF
CONSCIOUSNESS/COMA. INHAL : ANESTHETIC. IRRIT OF RESP TRACT & ACUTE
NERV SYS DEPRESS CHARACT BY FOLLOWING PROGRESSIVE STEPS: HDCH,
DIZZ, (ING 5)
Medical Cond Aggravated by Exposure:NONE LISTED IN LITERATURE.

First Aid:INGEST: DRINK 1-2 GLASSES OF H*2O TO DILUTE.KEEP PERSON WARM,
QUIET & GET MED ATTN. IMMED: DECISION TO INDUCE VOMIT MUST BE BASED
ON ADVICE OF PHYS/POIS CNTRL CNTR. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCON PERSON. INHAL: REMOVE FROM AREA TO FRESH AIR.RESTORE
BRTHG. CONSULT PHYS.EYE: IMMED BEGIN FLUSHING W/COOL H*2O,OCCAS
LIFTING LIDS TO ENSURE THORO RINSING. CONTINUE FOR AT LST 15 MIN.
(SUPDAT)

Flash Point:110F,43C
Lower Limits:1%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT
EQUIP.H*2O MAY BE USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILDUP &
POSS AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPARKS, FLAME & ELEC EQUIP. CLSD CNTNRS MAY EXPLO WHEN EXPOS
TO EXTREME HEAT. APPLIC TO HOT SURFS REQS SPEC(SUPDAT)

Spill Release Procedures:REMOVE SOURCES OF IGNITION. SOAK UP AND REMOVE
WITH INERT ABSORBENT MATERIAL WITH NON-SPARKING TOOLS. PROVIDE
ADEQUATE VENTILATION. USE APPROVED VAPOR RESPIRATOR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS AND
USE AWAY FROM HIGH TEMPERATURE, SPARKS AND FLAME. AVOID PROLONGED
CONTACT WITH SKIN.
Other Precautions:DO NOT INGEST. KEEP CONTAINER TIGHTLY SEALED WHEN NOT
IN USE. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:USE NIOSH/MSHA APPRVD PROPERLY FITTED MECH
RESP/MASK TO AVOID BRTHG VAP/SPRAY MIST DURING MIX,SPRAYING,
APPLIC/CURING. USE A TC 19C NIOSH/MSHA APPRVD PROPERLY FITTED POS
AIR SUPP RESP IN CONFINED AREA S/WHEN OVERSPRAY IS PRESENT. (SUPP
DATA)
Ventilation:PROVIDE SUFF VENT IN VOL & PATTERN TO KEEP AIR CONTAM CONC
BELOW APPLIC OSHA PEL/ACGIH'S TLV LIMIT. FOR BAKING (SUPDAT)
Protective Gloves:SYNTHETIC RUBBER GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:PROTECTIVE OVERALLS RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING. DISCARD
CONTAMINATED SHOES.
Supplemental Safety and Health
EXPLO HAZ: PREC.DURING EMER CNDTNS, OVEREXP TO DECOMP PRODS MAY CAUSE
HLTH HAZ.OBTAIN MED ATTN.FIRST AID PROC:WHILE FLUSHING EYES,SEND
FOR MED ASSIST.SKIN: WIPE OFF W/RAG & WASH THORO W/SOAP & H*2O.RE
SP PROT: CAREFULLY FOLLOW RESP MFR'S RECOM FOR USE.VENT: FINISHES,
VENT VAPORS EMITTED ON HEATING.

HCC:F4
Boiling Pt:B.P. Text:>280F,>138C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.12
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:50.2

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, BASES.
Stability Condition to Avoid:HIGH TEMPERATURE.
Hazardous Decomposition Products:MAY PRODUCE FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CO, CO*2, AND NO*2.

Waste Disposal Methods:DISPOSE IN SEALED METAL CONTAINER AWAY FROM HEAT
AND FLAME IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
DO NOT INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.